EXPERIMENTAL INVESTIGATION OF O2 AND CO2 MASS TRANSFER IN BIOREACTORS Original scientific paper

Main Article Content

Zeynep Yilmazer Hitit
https://orcid.org/0000-0001-9078-191X
Suna Ertunc
https://orcid.org/0000-0002-0139-7463
Bulent Akay
https://orcid.org/0000-0002-2541-490X
Murat Kaan Gulsoy
https://orcid.org/0009-0007-9243-4744
Emine Yagmur Ayindi
https://orcid.org/0009-0000-8599-1939
Ilayda Yilmaz
https://orcid.org/0009-0006-3159-0869
Rumeysa Yeten
https://orcid.org/0009-0008-7571-6691

Abstract

Gas–liquid mass transfer of oxygen (O2) and carbon dioxide (CO2) was studied experimentally in a stirred bioreactor. Oxygen kLa was measured by the dynamic method using nine combinations of agitation speed and gas flow rate, with two runs performed for each condition. Multiple linear regression explained 93.8% of the variation in kLa (R2 = 0.938), and the model was statistically significant (F = 114.0, p < 0.001). Over the range studied, gas flow rate had a greater effect on oxygen kLa than agitation speed. For the CO2 experiments, dissolved CO2 concentration was estimated from carbonate hardness (KH) and pH measure-ments using a simple and low-cost procedure. The U-shaped tubular and ring spargers were then compared under the same operating conditions. The U-shaped tubular sparger gave a slightly higher kLa (0.625 min⁻¹) than the ring sparger (0.59 min⁻¹) and showed a faster initial CO2 transfer. However, the ring sparger reached a higher final dissolved CO2 concentration, about 1300 mg/L compared with 1050–1080 mg/L for the U-shaped sparger. These results suggest that sparger performance should be considered in terms of both transfer rate and the final dissolved-gas concentration when selecting operating conditions for bioprocess applications.

Article Details

Section

Article

How to Cite

EXPERIMENTAL INVESTIGATION OF O2 AND CO2 MASS TRANSFER IN BIOREACTORS: Original scientific paper. (2026). Chemical Industry & Chemical Engineering Quarterly. https://doi.org/10.2298/CICEQ251119013H

Funding data

References

[1] J.L. Cotter, M.S. Chinn, A.M. Grunden, Enzyme Microb. Technol. 44 (2009) 281-288. https://doi.org/10.1016/j.enzmictec.2008.11.002.

[2] M. Melikoğlu, A. Albostan, J. Fac. Eng. Arch. Gazi Univ. 26 (2011) 151-160. https://dergipark.org.tr/tr/pub/gazimmfd/issue/6687/88723.

[3] S. Park, B. Ahn, Y. Kim, Bioresour. Technol. Rep. 6 (2019) 237-240. https://doi.org/10.1016/j.biteb.2019.03.012.

[4] H.N. Abubackar, M.C. Veiga, C. Kennes, Bioresour. Technol. 186 (2015) 122-127. https://doi.org/10.1016/j.biortech.2015.02.113.

[5] S.R. Trevethick, J.C. Bromley, S.D. Simpson, V. Khosla, US 8 178 330 B2 (2012). https://patentimages.storage.googleapis.com/df/29/85/0f281bcdaa487f/US8178330.pdf.

[6] M. Köpke, C. Mihalcea, J.C. Bromley, S.D. Simpson, Curr. Opin. Biotechnol. 22 (2011) 320-325. https://doi.org/10.1016/j.copbio.2011.01.005.

[7] J. Abrini, H. Naveau, E.-J. Nyns, Arch. Microbiol. 161 (1994) 345-351. https://doi.org/10.1007/BF00303591.

[8] P. Lee, S. Ni, S. Chang, S. Sung, S. Kim, Chem. Eng. J. 184 (2012) 268-277. https://doi.org/10.1016/j.cej.2011.11.103.

[9] D. Moutafchieva, D. Popova, M. Dimitrova, S. Tchaoushev, J. Chem. Technol. Metall. 48 (2013) 351-356. https://journal.uctm.edu/node/j2013-4/4-Chaushev%20-%20351-356.pdf.

[10] T. Moucha, V. Linek, E. Prokopova, Chem. Eng. Sci. 58 (2003) 1839-1846. https://doi.org/10.1016/S0009-2509%2802%2900682-6.

[11] G. Arın, Kimya Mühendisliğinde Kütle Aktarımı, Sivas (2006), pp. 56-58. ISBN: 9944-5130-0-8.

[12] P.C. Munasinghe, S.K. Khanal, Biotechnol. Prog. 26 (2010) 1616-1621. https://doi.org/10.1002/btpr.473.

[13] A. Kapic, A. Jones, S. Heindel, L. Theodore, Ind. Eng. Chem. Res. 45 (2006) 9150-9155. https://doi.org/10.1021/ie060655u.

[14] F. Scargiali, A. Busciglio, F. Grisafi, A. Brucato, Chem. Eng. Trans. 20 (2010) 229-234. https://doi.org/10.3303/CET1020039.

[15] V. Linek, V. Vacek, P. Beneš, Chem. Eng. J. 34 (1987) 11-34. https://doi.org/10.1016/0300-9467%2887%2985003-7.

[16] J. Zosel, W. Oelßner, M. Decker, G. Gerlach, U. Guth, Meas. Sci. Technol. 22 (2011) 072001. https://doi.org/10.1088/0957-0233/22/7/072001.

[17] L. Kortazar, B. Duval, O. Liñero, O. Olamendi, A. Angulo, D. Amouroux, A. de Diego, L.A. Fernandez, Microchem. J. 152 (2020) 104345. https://doi.org/10.1016/j.microc.2019.104345.

[18] P.M. Doran, K. Morrissey, R.P. Carlson, Bioreactor Mass Transfer, in Bioprocess Engineering Principles, 3rd ed., P.M. Doran, K. Morrissey, R.P. Carlson, Eds., Academic Press, Amsterdam (2024), pp. 291-351. https://doi.org/10.1016/B978-0-12-822191-4.00009-9.

[19] A. Kapic, T.J. Heindel, Chem. Eng. Res. Des. 84 (2006) 239-245. https://doi.org/10.1205/cherd.05117.

[20] L. McDonnell, D. Yusufu, C. O’Rourke, A. Mills, Sens. Actuators B 412 (2024) 135859. https://doi.org/10.1016/j.snb.2024.135859.

[21] F. Garcia-Ochoa, E. Gomez, Biotechnol. Adv. 27 (2009) 153-176. https://doi.org/10.1016/j.biotechadv.2008.10.006.

[22] A. Yawalkar, A.B.M. Heesink, G.F. Versteeg, V.G. Pangarkar, Can. J. Chem. Eng. 80 (2002) 840-848. https://doi.org/10.1002/cjce.5450800507.

[23] K. Akita, F. Yoshida, Ind. Eng. Chem. Process Des. Dev. 12 (1973) 76-80. https://doi.org/10.1021/i260045a015.

[24] W.-D. Deckwer, R. Burckhart, G. Zoll, Chem. Eng. Sci. 29 (1974) 2177-2188. https://doi.org/10.1016/0009-2509(74)80025-4.

[25] H. Hikita, S. Asai, K. Tanigawa, K. Segawa, M. Kitao, Chem. Eng. J. 22 (1981) 61-69. https://doi.org/10.1016/0300-9467(81)85006-X.

[26] E. Sada, H. Kumazawa, C. Lee, N. Fujiwara, Ind. Eng. Chem. Process Des. Dev. 24 (1985) 255-261. https://doi.org/10.1021/i200029a006.

[27] R.A. Bello, C.W. Robinson, M. Moo-Young, Chem. Eng. Sci. 40 (1985) 53-58. https://doi.org/10.1016/0009-2509(85)85046-6.

[28] A. Karimi, A.J. Jolodar, A.A. RajabPour, H.R. Bakhtiary, Pet. Coal 49 (2007) 27-33. https://vurup.sk/download/2496/2535.

[29] A. Sánchez Mirón, F. García Camacho, A. Contreras Gómez, E. Molina Grima, Y. Chisti, AIChE J. 46 (2000) 1872-1887. https://doi.org/10.1002/aic.690460915.

[30] K.H. Choi, W.K. Lee, J. Chem. Technol. Biotechnol. 56 (1993) 51-58. https://doi.org/10.1002/jctb.280560110.

Similar Articles

You may also start an advanced similarity search for this article.